How to Build a Solar Still

Some redwood boards, a large black towel, copper pipe, a glass pane, screws, and these plans are all you need to make a solar still that will purify more than a gallon a day of salt water.

  • 029 solar still - illustration 2
    The finished solar still looks something like this.
  • 029 solar still - fig 1
    Diagram shows solar still parts and assembly method.
  • 029 solar still fig 2
    Cut the 1-by-4 redwood side pieces to the proper length. Drill a 1/8-inch hole as a guide, and then drill three 5/8inch holes and one 3/4-inch hole.
  • 029 solar still - fig 3
    For the bad water trough, drill a hole in the very center of the angle iron to receive the center 1/4-inch copper drain tube.
  • 029 solar still - illustration 1
    Slip the towel loop onto the support tubes inside the box.

  • 029 solar still - illustration 2
  • 029 solar still - fig 1
  • 029 solar still fig 2
  • 029 solar still - fig 3
  • 029 solar still - illustration 1

Ninety years ago, mine owners in the high country of Chile were faced with the problem of providing drinking water for their workers. The only available supply was unfit to drink, and so a means of purifying the liquid had to be found. Amazingly, the solution was a sun-operated distilling plant in which a large area of glassed-over wooden frames evaporated the contaminated water, recondensed it, and thus produced as much as 6,000 gallons of fresh water in a day!

This solar still used no fuel or power except that from the sun's rays and was thus able to provide pure water at a cost unmatched by any other means of distillation. Oddly, the method was forgotten in the intervening years and fuel operated stills were used whenever it was necessary to convert salty—or otherwise undrinkable water—to fresh.

Not until World War II were solar stills used again except by experimenters. Fliers forced down at sea needed a source of supply of drinking water until they could be rescued. Dr. Maria Telkes developed an inexpensive, lightweight plastic still that could be included in even one-man life rafts and that would produce a quart of fresh water a day.

Since that time Dr. Telkes and other scientists have worked with solar stills of various sizes. Our government's Department of the Interior is interested in the idea, and plans have been made for large seacoast installations to purify salt water for drinking and irrigation. In some designs no pumps would re needed because the sea itself would fill the condensing tanks at high tide.

At present it is felt that the cost of such a system would be too high, even considering that cost of operation would be less than that of a fuel-run still. Engineers are hopeful, however, that improved methods and materials will make the plan feasible.

The principle of the solar still is a simple one, and is observed on a grand scale in nature. Clouds are droplets of water evaporated from the surface of the sea or from damp ground and then condensed high in the air. In the process of evaporation, solids such as salt are left behind. Many readers will be familiar with the commercial harvesting of salt in shallow ponds, for this is one of the oldest of man's uses of solar energy.

Jasmine Mah
5/13/2012 7:45:39 PM

Can't the water get contaminated with aluminum when it runs down the foil? Maybe it's better to put some kind of safe coating over it

2/26/2009 12:26:42 PM

Has anyone experimented with a solar still for fuel alcohol?



Fall 2021!

Put your DIY skills to the test throughout November. We’re mixing full meal recipes in jars, crafting with flowers, backyard composting, cultivating mushrooms, and more!


Subscribe Today - Pay Now & Save 64% Off the Cover Price

50 Years of Money-Saving Tips!

Mother Earth NewsAt MOTHER EARTH NEWS for 50 years and counting, we are dedicated to conserving our planet's natural resources while helping you conserve your financial resources. You'll find tips for slashing heating bills, growing fresh, natural produce at home, and more. That's why we want you to save money and trees by subscribing through our earth-friendly automatic renewal savings plan. By paying with a credit card, you save an additional $5 and get 6 issues of MOTHER EARTH NEWS for only $12.95 (USA only).

You may also use the Bill Me option and pay $17.95 for 6 issues.

Canadian Subscribers - Click Here
International Subscribers - Click Here
Canadian subscriptions: 1 year (includes postage & GST).

Facebook Pinterest Instagram YouTube Twitter flipboard

Free Product Information Classifieds Newsletters