Mother Earth News

HOT TOPICS >> Better mpg • Trespassing • Plant Now • Potatoes • Ethanol

Ask Our Experts > Do It Yourself

Ask your question, get an answer:

Question:
Name:   
City: State:
Email:

There are several ways to approach this common problem.

The number one reason small engines don’t start is that they are out of fuel. Be sure the tank isn’t empty and the fuel shutoff (if equipped) isn’t closed. Once you are certain (or pretty certain) fuel is getting to the carburetor or injection system (turn the engine over and check for gasoline fumes in the exhaust) you should check the ignition system.

Is the engine “turned on”? Look for a switch (and be sure it is in the on position) or a metal lever in contact with the tip of the spark plug (and flip it away from the plug).

If the machine is pull started or an older battery started model and the engine cranks over, check to be sure that all the safety interlock switches are closed. If it is a lawn tractor, the switches might be associated with the PTO lever, seat, clutch/brake pedal and/or gear selector lever. If it is a walk-behind machine, check that the PTO clutch (if equipped) is disengaged and blade-brake handle or other interlock handles are in the correct starting position(s) and their linkages are taut. If the interlock switches aren’t closed, the current required to energize the coil (or other ignition components) won’t be able to flow. In very simple systems, the engine’s on-off switch is nothing more than a ground circuit that acts on the high-voltage side of the ignition.

If the engine still won’t start, there might be a problem with the ignition timing, high-voltage generation or the sparkplug itself. Even if you aren’t mechanically inclined, before calling a mechanic, carefully remove a sparkplug and situate it so the hexagonal portion of the plug and engine block are in contact. Turn the engine over while focusing on the plug’s electrode (formerly located inside the engine). If the plug is firing, you will hear a snap and see a spark at the electrode. If the plug’s electrode is fouled with thick, crusty carbon or other material, replace it with a new one and see what happens.

If the engine still doesn’t start, it might be time to call a friend. The fix might be simple. For example in battery-ignited systems, perhaps the wire that charges the high-voltage source is broken or shorted. In magneto-fired engines there might be a problem with the magneto’s stator — or possibly the magnet slipped out of position. It’s also possible the ignition points (if the engine has them) need adjusting or replacement. The non-start syndrome might also be caused by a leaking cylinder head gasket or any of a number of other less likely possibilities.

— Oscar H. Will III, editor, Grit magazine
Pat Berka 5/7/2008 8:17:56 AM

My experience has been that moisture apparently accumulates in the gas tank over the winter, and the engine will not continue running after the initial crank up/start. The best solution for that problem is to use one of the products on the market that will evaporate the water out of the tank. There are three good ones that I have used successfully. Another tip that helps an engine burn cleaner and more efficiently is to use about a capful of RX-P in a full tank of the engine. RX-P is the gasoline additive that is used in cars to eliminate emissions.

0 Comments
Respond
Dale 5/7/2008 8:46:07 AM

Ditto on the water in fuel. Also cleaning, if you have no choice, or replacing the spark plug. You can buy an aresol can of starting fluid @ Big Lots for .99 that will get an engine with a weak spark to start, and usually after it warms up it will keep running for the day. You simply remove the air cleaner, spray the fluid into the intake and try to start the engine. Clean or replace the filter [very important] and put it back in place on the engine and you can get back to work!

0 Comments
Respond
Scott Krabler 5/7/2008 10:13:14 AM

Another common issue I'd try before getting into all the engine troubleshooting is clean, fresh gasoline. If gasoline sits in the tank all winter and you try to start it in the spring, it's likely the motor will not start. Old (6 months), spoiled gasoline needs to be drained and refilled with clean fuel each season.

0 Comments
Respond
Add Your Comment

You can use this comment form to enter your personal experiences, or additional information and resources that you'd like to share with Mother Earth News readers. Your helpful advice will be posted on this page.




Comments
(Offensive materials and/or spam will be removed, no HTML allowed)

Please Note: Your sign-up must be verified via e-mail before your comment is published.